TSB : EXPERTEC TSB (88-3-5)

Details

WARNING: This page is about the Electra Base, 2D Coupe, which is a different variant/trim than selected. Publication date: 1987-11-16 Reference number: 88-3-5 EXPERTEC TSB EXPERTEC TSB TECHNICAL SERVICE BULLETIN Reference Number(s): 88-3-5, Date of Issue:  11/16/87 TIRE WARRANTIES - IRREGULAR/PREMATURE WEAR Model(s): All Buick Models Bulletin No.: Buick 88-3-5 Date: 11/16/1987 BULLETIN ILLUSTRATION LIST Fig 1: Graphic Fig 2: Graphic Fig 3: Graphic Fig 4: Graphic SERVICE INFORMATION As in the past, tires continue to be warranted by the tire manufacturer against defects in material or workmanship. Details of this limited warranty may be found in each tire company warranty booklet, which is part of the glove box material. The GPI Warranty and Owner Assistance Booklet also now states that the GM dealer will assist the customer in obtaining a tire adjustment, if necessary. Tire conditions caused by vehicle defects are warranted by General Motors., This statement is now included in the GM Warranty and Owner Assistance Booklet. This applies during the basic coverage period, which is 12 months/12,000 miles, and should be applied to all past and current models. Examples of tire conditions that fall within GM's responsibility may include tire damage during vehicle assembly, tire damage due to tire-to-vehicle interference, and irregular/premature tire wear. Tire wear due to abusive driving is not covered by warranty. Irregular/premature tire wear is aggravated by excessive toe-in (or toe-out). Excessive camber can also be a contributor, as can operating cond-I tions such as city driving with a lot of cornering. Irregular tire wear usually occurs on non-drive axles, such as the front wheel positions of rear drive vehicles. An early indication may be an increase in tire noise. In most cases, modified "X" tire rotation, which is a scheduled maintenance at 7500 miles, will equalize tire wear (See Fig 1 ). Some amount of wear is expected and should be considered normal. Only when the cross grooves in the tread disappear within 12,000 miles should the tires be replaced under Warranty (See Fig 2 ). Even when these grooves disappear, however, the tire is normally only half worn in this area. Whenever tires are replaced for this reason, alignment should be checked and reset to specification, if necessary. If tires are needed for any of the above conditions, they should be purchased from your local tire outlet. If tires are not readily available, each tire nianufacturer has a toll-free assistance line for dealers. These numbers have been previously provided. WARRANTY INFORMATION The tire invoice amount should be entered as a net item on the warranty claim. Labor Code E0420, Replace Wheel and/or Tire, should be used. See Fig 1 This Rotation Pattern eventually gets each tire on all four positions. It gets those tires on the Non-Drive Axle, which are most prone to irregular wear, to turn in the opposite direction. This will equalize wear quickest, and tire noise related to tread wear will actually become quieter after a few thousand miles.